Product ID:ELAST-A-TRIM SG ENAMEL, 6300 V
MSDS Date:06/01/1992
FSC:8010
NIIN:00N018374
MSDS Number: CBBCC

EVR-GARD COATINGS CO

16400 GARFIELD AVE
PARAMOUNT, CA 90723
US

Emergency Phone: 310-531-0131

Info Phone: 310-531-0131

Cage: 5G582

EVR-GARD COATINGS CO

PARAMOUNT, CA 90723 US

Telephone: 310-531-0131

Cage: 5G582

KEROSENE (PETROLEUM), HYDROTREATED; (505 MINERAL SPIRITS)

CAS: 64742-47-8

RTECS: OA5504000

Fraction By Weight: 15.94%

OSHA PEL 125 PPM (MFR)

ACGIH TLV: 125 PPM (MFR)

1.99 LB/GAL (238 G/L)

RTECS: 9999999VO

OSHA PEL N/K

ACGIH TLV: N/K

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:INHAL: EXCESSIVE INHAL OF VAPORS MAY
RESULT IN DIZZINESS & HEADACHES. UNCONSCIOUSNESS IN EXTREME CASES.
IRRITATION OF NOSE, THROAT & EYES, WEAKNESS, FATIGUE, NAUSEA.
SYMPTOMS DISAPPEAR WHEN EXPOS CEAS ES. SKIN & EYES: IRRITATION.
IRRITANT IF ABSORBED. AFFECTED AREA WILL SHOW SIGNS OF REDNESS &
RASH IF (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ: NOT WASHED W/SOAPY WATER IMMED.
INGEST: IRRITATION OF THE RESPIRATORY TRACT CHARACTERIZED BY
HEADACHE, DIZZINESS, STAGGERING, CONFUSION & UNCONSCIOUSNESS & COMA
IN EXTREME CASES. REPORTS HAV E SHOWN RPTD & PRLNGD OCCUPATIONAL
OVEREXP TO SOLVENTS CAN CAUSE PERMANENT BRAIN DAMAGE & NERVOUS
SYSTEM DAMAGE.
Medical Cond Aggravated by Exposure:PROLONGED OR REPEATED CONTACT MAY
CAUSE DERMATITIS.

First Aid:INHAL: REMOVE TO FRESH AIR. EYES: FLUSH WITH PLENTY OF WATER
FOR AT LEAST 15 MINUTES. SKIN: REMOVE CONTAMINATED CLOTHING AND
WASH SKIN WITH SOAPY WATER THOROUGHLY. APPLY LOTION OR OIL TO
AFFECTED AREA S AFTER THOROUGH WASHING. INGEST: DO NOT INDUCE
VOMITING. CALL MD IMMEDIATELY.

Flash Point:105F,41C
Lower Limits:1.0%
Extinguishing Media:FOAM, ALCOHOL FOAM, CARBON DIOXIDE, DRY CHEMICAL,
WATER FOG.
Fire Fighting Procedures:NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP
FIGHT AS VOLAT LIQ FIRE. CLSD CNTNRS MAY EXPLODE WHEN EXPOS TO
EXTREME HEAT. KEEP AWAY FROM AREAS EXPOS TO FIRE.
Unusual Fire/Explosion Hazard:AVOID APPLICATION IN AREAS OF PILOT
LIGHTS, SPKS OR OTHER IGNIT SOURCES AS VAPS MAY ACCUM ON FLOOR &
IGNITE. KEEP CNTNRS CLSD TIGHTLY & STORE IN A COOL (SUPDAT)

Spill Release Procedures:ABSORB SPILLED MATERIAL WITH ABSORBENTS SUCH
AS SAWDUST, CLAYS, ETC AND FLUSH SPILL AREA WITH LOTS OF WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:DO NOT STORE NEAR OPEN FLAME OR
SOURCES OF IGNIT. DO NOT STORE IN HIGH TEMP STORAGE. IN CASE OF
FIRE, REMOVE CLSD CNTNRS FROM AREAS EXPOSED TO FIRE.
Other Precautions:EMPTY CONTAINERS USUALLY STILL HOLD RESIDUES OF
MATERIAL AND VAPORS. THESE MUST BE CONSIDERED HAZARDOUS AND
DISPOSED OF IN ACCORDANCE WITH PROPER HANDLING PROCEDURES
PRESCRIBED FOR HAZARDOUS CHEMICALS .

Respiratory Protection:THE USE OF NIOSH/MSHA APPRVD RESPS IS RECOM WHEN
USING SOLV BASED COATINGS. WHEN LEVEL OF SOLV VAPS IS NOT KNOWN OR
EXCEEDS LEVEL AT WHICH REGULAR RESPS ARE EFTIVE, USE OF NIOSH/MSHA
APPRVD RESPS SUCH AS TC-19C-NIOSH/MSHA IS HIGHLY RECOM.
Ventilation:BE SURE TO PROVIDE ADEQ VENT IN ALL WORKING AREAS AT ALL
TIMES. SERIOUS HLTH PROBS COULD RSLT FROM RPTD & PRLNGD EXPOS.
Protective Gloves:NEOPRENE, BUNA N GLOVES.
Eye Protection:ANSI APPRVD CHEM WORKERS GOGGLES .
Other Protective Equipment:ANSI APPROVED EYE WASH & DELUGE SHOWER . USE
GLOVES & GOGGS TO PROTECT AGAINST ACCIDENTAL SPLASHING OF (SUPDAT)
Work Hygienic Practices:STANDARD HYGIENIC PRACTICES MUST BE OBSERVED
WHEN HANDLING THIS PRODUCT AND ALL CHEMICALS.
Supplemental Safety and Health
FIRE FIGHT PROC: PLACE WHEN NOT IN USE. OTHER PROT EQUIP: LIQS ONTO
SKIN & IN EYES. AVOID PRLNGD CNTCT OVEREXP. PROVIDE ADEQ VENT AT
ALL TIMES WHEN APPLYING THIS PRODUCT.

Boiling Pt:B.P. Text:168F,76C
Vapor Pres:SEE ING
Vapor Density:HVR/AIR
Spec Gravity:1.5 (H*2O=1)
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:NOT SOLUBLE
Appearance and Odor:WHITE PAINT AND COLORS; PAINT THINNER ODOR.

Stability Indicator/Materials to Avoid:YES
STRONG ACIDS OR ALKALIS. LONG TERM CONTACT WITH WATER.
Stability Condition to Avoid:AVOID OPEN FLAMES, WELDING ARCS OR OTHER
HIGH TEMPERATURE SOURCES WHICH INDUCE THERMAL DECOMPOSITION AND
FIRE.
Hazardous Decomposition Products:THERMAL DECOMPOSITION MAY YIELD CARBON
DIOXIDE AND/OR CARBON MONOXIDE.

Waste Disposal Methods:DISPOSE OF ALL WASTES INCLUDING ABSORBENTS USED
TO CLEAN UP SPILLS INTO 55-GAL METAL CONTAINERS AND DISPOSE IN
APPROVED DUMPSITE IN ACCORDANCE WITH PRESCRIBED FEDERAL, STATE AND
LOCAL REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.